1984 Chevrolet G20 recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-21. Recalls apply to specific VINs — run your VIN to confirm.
3 safety recalls, most serious first
1. Equipment
What's wrong, in plain English: A part or accessory supplied with the vehicle. CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE…
What could happen: THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
The fix: HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1984 G20.
- Book a repair at any authorized Chevrolet dealer. Quote NHTSA campaign 07E088000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-890-2075.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: EQUIPMENT
Summary: CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence: THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Remedy: HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes: CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
2. Seat belts
What's wrong, in plain English: Seat belts may not hold you in a crash.
What could happen: OCCUPANTS WOULD NOT BE ADEQUATELY PROTECTED IN EVENT OFAN ACCIDENT OR SUDDEN STOP.
The fix: INSTALL PROPER MOUNTING HARDWARE AND SEAT BELTS.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1984 G20.
- Book a repair at any authorized Chevrolet dealer. Quote NHTSA campaign 90V137000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: SEAT BELTS:FRONT:ANCHORAGE
Summary:
Consequence: OCCUPANTS WOULD NOT BE ADEQUATELY PROTECTED IN EVENT OFAN ACCIDENT OR SUDDEN STOP.
Remedy: INSTALL PROPER MOUNTING HARDWARE AND SEAT BELTS.
Notes: NOTE: THIS RECALL WAS INITIALIZED BY MARK III INDUSTRIES.SYSTEM: SEAT BELTS, SEAT BELT ANCHORS, AND SEAT MOUNTING. DOM: SEPT. 1978 TOSEPT. 1984.DESCRIPTION ON DEFECT: IMPROPER MOUNTING HARDWARE AND IMPROPER SAFETY RESTRAINTSYSTEMS MAY HAVE BEEN INSTALLED IN THESE VEHICLES.
3. Equipment
What's wrong, in plain English: A part or accessory supplied with the vehicle. PLASTIC PLUG LOCATED ON TOP OF THE FRONT AIR CONDITIONER WAS NOT REMOVED DURING ASSEMBLY. THIS DEFECT DISRUPTS NORMAL OPERATION OF EVAPORATOR BLOWER HOUSING.
What could happen:
The fix: REAR A/C SYSTEM BLOWER WILL BE INSPECTED FOR DAMAGE SUCH AS MELTING OR BURNING. IF NO DAMAGE IS DETECTED, THE RESISTOR WILL BE REPLACED AND ANY REMAINING PIECES WILL BE REMOVED. IF DAMAGE IS DETECTED, THE RESISTOR AND THE A/C EVAPORATOR INLET CASE WILL BE REPLACED.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1984 G20.
- Book a repair at any authorized Chevrolet dealer. Quote NHTSA campaign 84V095000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: EQUIPMENT:APPLIANCE:AIR CONDITIONER
Summary: PLASTIC PLUG LOCATED ON TOP OF THE FRONT AIR CONDITIONER WAS NOT REMOVED DURING ASSEMBLY. THIS DEFECT DISRUPTS NORMAL OPERATION OF EVAPORATOR BLOWER HOUSING.
Consequence:
Remedy: REAR A/C SYSTEM BLOWER WILL BE INSPECTED FOR DAMAGE SUCH AS MELTING OR BURNING. IF NO DAMAGE IS DETECTED, THE RESISTOR WILL BE REPLACED AND ANY REMAINING PIECES WILL BE REMOVED. IF DAMAGE IS DETECTED, THE RESISTOR AND THE A/C EVAPORATOR INLET CASE WILL BE REPLACED.
Notes: VEHICLE DESCRIPTION: TRUCKS (VANS) EQUIPPED WITH FRONT AIR CONDITIONERS.SYSTEM: VENTILATION; AIR CONDITIONER.CONSEQUENCES OF DEFECT: ENGINE FIRE COULD START WITHOUT WARNING AND CAUSE FIREDAMAGE TO VEHICLE AND INJURY TO PASSENGERS.
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- 1984 Chevrolet G20 owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Engine (1), Equipment (1), Transmission / drivetrain (1).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (3)
01/29/1998 · Engine
WHEN DRIVING THE VEHICLE STALLS OUT WHEN THE ACCELERATOR IS APPLIED. DEALER CAN'T FIND THE PROBLEM. *AK
01/23/1997 · Equipment
RADIO INOPERATIVE.
01/23/1997 · Transmission / drivetrain
TRANSMISSION FAILED.