2003 Buick Rendezvous recalls & complaints

Component: FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
Summary: CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Consequence: FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Remedy: DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Notes: THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PRESSURE REGULATORS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED BY GENERAL MOTORS. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

Component: FUEL SYSTEM, GASOLINE:STORAGE
Summary: ON CERTAIN VEHICLES, VARIATIONS IN THE MANUFACTURING PROCESS OR EXPOSURE TO HIGH AMBIENT TEMPERATURES MAY LEAD TO FRACTURE OF THE FUEL TANK INLET CHECK VALVE (ICV).
Consequence: A FRACTURE MAY ALLOW FUEL VAPORS TO PASS THROUGH AND ALLOW DROPLETS OF FUEL TO ACCUMULATE ON THE SIDE OF THE FUEL TANK. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL TANK. THE RECALL WILL BE MAILED IN TWO PHASES WITH THE FIRST PHASE BEGINNING ON DECEMBER 4, 2007. THE SECOND PHASE WILL BE MAILED ON DECEMBER 13, 2007. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OR PONTIAC AT 1-800-620-7668. THE VEHICLE POPULATION INCLUDES BUICK RENDEZVOUS AND PONTIAC AZTEK VEHICLE BUILT IN MAY 2003; CHEVROLET VENTURE AND PONTIAC MONTANA VEHICLES BUILT FROM JUNE THROUGH AUGUST 2002; AND ALL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO, AND HAWAII.
Notes: GM RECALL NO. 06230. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

Component: LATCHES/LOCKS/LINKAGES:HATCHBACK/LIFTGATE:LOCK
Summary: ON CERTAIN SPORT UTILITY VEHICLES, A STRUCTURAL SUPPORT AT THE LATCH ATTACHMENT IN THE REAR LIFTGATE MAY BE INADEQUATE TO RETAIN THE LATCH TO THE LIFTGATE IN CERTAIN SEVERE VEHICLE CRASH EVENTS.
Consequence: IF THE LIFTGATE WERE TO OPEN IN A VEHICLE CRASH, AN OCCUPANT COULD BE EJECTED FROM THE VEHICLE RESULTING IN INCREASED RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL ADD STRUCTURAL REINFORCEMENTS TO THE LIFTGATE IN THE AREA ADJOINING THE LATCH ASSEMBLY. OWNER NOTIFICATION SCHEDULE BEGAN ON JUNE 21, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080. THIS IS AN EXPANSION TO A PREVIOUS RECALL (03V211).
Notes: GM RECALL NO. 03030. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Component: STEERING
Summary: IN SOME OF THESE SPORT UTILITY VEHICLES, THE DIAMETER OF THE STEERING COLUMN INTERMEDIATE SHAFT IS TOO SMALL.
Consequence: THIS CONDITION COULD ALLOW THE INTERMEDIATE SHAFT TO SPIN INSIDE THE STEERING COLUMN COUPLING, RESULTING IN LOSS OF STEERING CONTROL OF THE VEHICLE. IF THIS WERE TO HAPPEN WHILE THE VEHICLE IS MOVING, A CRASH COULD RESULTING WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL INSPECT, AND REPLACE IF NECESSARY, THE STEERING COLUMN INTERMEDIATE SHAFT. OWNERS WERE NOTIFIED BY TELEPHONE ON FEBRUARY 7, 2003, WITH A FOLLOW-UP LETTER ON FEBRUARY 11, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300 OR PONTIAC AT 1-800-762-2737.
Notes: GM RECALL NO. 03009. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Component: AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE
Summary: ON CERTAIN MINI VANS, PASSENGER AND SPORT UTILITY VEHICLES, SOME OF THESE VEHICLES HAVE A DRIVER'S SIDE AIR BAG THAT MAY NOT DEPLOY AS DESIGNED. IN ADDITION, THE AIR BAG INFLATOR COULD RUPTURE.
Consequence: THIS COULD RESULT IN REDUCED CAPABILITY OF THE AIR BAG TO PROTECT THE DRIVER. ALSO IF THE AIR BAG INFLATOR RUPTURED, PIECES OF THE INFLATOR COULD STRIKE AND INJURE THE VEHICLE OCCUPANTS.
Remedy: DEALERS WILL INSPECT, AND IF NECESSARY, INSTALL A NEW DRIVER'S AIR BAG. OWNER NOTIFICATION BEGAN ON MARCH 11, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR PONTIAC AT 1-800-762-2737.
Notes: GM RECALL NO. 03008. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Component: EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Summary: CERTAIN MINIVANS, PASSENGER AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." THE OWNER'S MANUAL DOES NOT EXPLAIN THE MEANING OF THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT LOWER UNIVERSAL ANCHORAGE SYSTEM.
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THEIR OWNER'S MANUAL. THIS SUPPLEMENT DESCRIBES AND SHOWS THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT ANCHORS THAT ARE LOCATED IN THE VEHICLE AND ON THE CHILD RESTRAINT OR BOOSTER CUSHION. OWNER NOTIFICATION BEGAN AUGUST 18, 2003. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Notes: GM RECALL NO. 03039. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Component: AIR BAGS:FRONTAL
Summary: CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence: PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Remedy: DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Notes: GM RECALL NO. 02032. ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

03/15/2022 · Airbags
The gas gage has been off since I bought it in September 2018. I run out of gas right before 1/4 of a tank and when I fill it it goes about 1/4 over the full line. The passenger seat side airbag went off closing the door May 2019.

02/15/2022 · Fuel system
After filling the fuel tank there is a strong gas odor that is present until the tank is almost empty. When walking around the vehicle or loading/unloading the vehicle, the strong gas odor is always present. This vehicle was at a dealership and they took it to the local personal auction company where i bid on it and bought it along with household items.

09/30/2021 · Fuel system
I purchased this vehicle in 2013, and a few years later, I began smelling gas. After doing my due diligence, I found out that there is a recall for this issue, because the check inlet valve at the top of the tank where the filler neck connects to the tank is cracked. Great, NO, only CERTAIN Rendezvous were covered, and even though mine has the exact same is…

05/06/2021 · Fuel system
HAVE BEEN TOLD BY SEVERAL DIFFERENT MECHANICS THAT FUEL IS LEAKING WHERE THE FUEL FILLER NECK CONNECTS TO THE PLASTIC GAS TANK AT THE CHECK INLET VALVE. I'VE SEEN MANY, MANY COMPLAINTS OF THIS SAME ISSUE FROM OTHER RENDEZVOUS OWNERS, AS WELL AS THE SAME PROBLEM OF GM AND/OR BUICK REFUSING TO REPAIR THE VEHICLE, EVEN THOUGH IT IS A SAFETY ISSUE, (POSSIBLE FU…

11/11/2020 · Fuel system
OUR RENDEVOUZ PLASTIC FUEL TANK STARTED SEEPING FUEL AT THE FILLER NECK YESTERDAY. AFTER DOING SOME READING, I SAW THERE WAS A RECALL AND THEN A SPECIAL COVERAGE ADJUSTMENT. THE ONE LISTED ON JULY 21, 2008 SAID THE TANK WOULD BE REPLACED REGARDLESS OF AGE AND MILEAGE. THEN, GM CHANGED THEIR MIND ON AUGUST 8, 2008 AND LIMITED MILEAGE AND AGE TO 150,000 MILES…

07/23/2020 · Fuel system
GAS TANK LEAKS SOMETIMES... WHEN IN MOTION AND WHEN STATIONARY

04/27/2020 · Fuel system
FUEL DRIPPING FROM TANK DUE TO CRACK AROUND INLET

01/14/2020 · Fuel system
STRONG SMELL OF GAS OUTSIDE THE RENDEZOUS AT FIRST AFTER FILLING CAR WHICH SEEM TO OCCUR ONLY WHEN NEWLY FILLED. NOW THE STRONG SMELL OUTSIDE OF CAR IS CONTINUOUS AND FUEL IS LEAKING. THIS IS A SUBJECT OF RECALL BUT DATE OF RECALL IS TOO OLD FOR GM TO HONOR THE RECALL. HAVE BEEN TOLD THAT THE FUEL TANK HAS TO BE REPLACED.