2004 Buick Regal recalls & complaints

Component: ENGINE AND ENGINE COOLING:ENGINE
Summary: General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engine’s front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Component: ENGINE AND ENGINE COOLING:ENGINE
Summary: General Motors LLC (GM) notified the agency on April 2, 2015, that they are is recalling certain model year 2004 Buick Regal vehicles manufactured April 9, 2003, to June 1, 2003, 2004 Chevrolet Impala vehicles manufactured April 8, 2003, to June 23, 2003, and 2004 Chevrolet Monte Carlo vehicles manufactured April 7, 2003, to June 23, 2003. On May 18, 2015, GM expanded the recall to cover an additional 49,751 2004 Pontiac Grand Prix vehicles manufactured January 6, 2003, to June 25, 2004. In the affected vehicles, the valve cover gasket may leak.
Consequence: The leaking engine oil can drip onto the hot surface of the exhaust manifold, increasing the risk of a fire.
Remedy: GM will notify owners, and dealers will remove the plastic cover and plastic oil fill tube extension and replace the front valve cover and gasket. These repairs will be done free of charge. The recall began on April 24, 2015. Owners may contact Buick customer service at 1-800-521-7300, Pontiac customer service at 1-800-762-2737 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 14574.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Component: STEERING
Summary: DORMAN PRODUCTS IS RECALLING 3,900 INTERMEDIATE STEERING SHAFTS DORMAN PART NOS. 425-151, 425-152, AND 425-153, (SOLD UNDER DORMAN'S "OE SOLUTIONS" BRAND NAME), BALKAMP #'S 7-3057, 7-3058, 7-3059 (SOLD UNDER THE "NAPA" BRAND NAME), AND PLATINUM PARTS #'S 2425151, 2425152, AND 2425153 MANUFACTURED DURING THE MONTH OF SEPTEMBER 2007. THESE REPLACEMENT STEERING SHAFTS CAN BE USED ON THE VEHICLES LISTED ABOVE. THE WELD CONNECTING THE INNER TUBE TO THE OUTER TUBE MAY BE DEFECTIVE.
Consequence: IF THE WELD FAILS, LOSS OF STEERING COULD RESULT, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy: DORMAN WILL NOTIFY OWNERS AND REPLACE THE STEERING SHAFTS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 16, 2008. OWNERS MAY CONTACT DORMAN TOLL FREE AT 1-800-523-2492.
Notes: THIS RECALL ONLY PERTAINS TO DORMAN'S OE SOLUTIONS BRAND NAME, BALKAMP'S NAPA BRAND, AND THE PLATINUM BRAND STEERING SHAFTS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS CORPORATION. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

Component: STEERING
Summary: DORMAN IS RECALLING 979 STEERING KNUCKLES, DORMAN P/NOS. 697-902 AND 697-903, SOLD UNDER DORMAN'S "OE SOLUTIONS<SUP>TM</SUP>" BRAND NAME, AND NAPA P/NOS. 7-8502 AND 7-8503 WHICH WERE SOLD FOR REPLACEMENT USE ON THE VARIOUS VEHICLES LISTED ABOVE. A POTENTIAL MATERIAL OR DESIGN DEFECT COULD RESULT IN THE STEERING KNUCKLE BREAKING IN THE HUB AREA.
Consequence: A BROKEN STEERING KNUCKLE COULD RESULT IN LOSS OF STEERING CONTROL AND A POSSIBLE CRASH WITHOUT WARNING.
Remedy: DORMAN WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE STEERING KNUCKLES FREE OF CHARGE AND REIMBURSE THE REPAIR FACILITY OR OWNER FOR LABOR. THE RECALL BEGAN ON FEBRUARY 23, 2009. OWNERS MAY CONTACT DORMAN'S TOLL-FREE HOTLINE AT 1-800-523-2492 AND PRESS 5.
Notes: THIS RECALL ONLY PERTAINS TO AFTERMARKET DORMAN STEERING KNUCKLES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS CORPORATION. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

12/08/2020 · Electrical system
ALL 4 POWER WINDOW MOTORS DO NOT WORK. THEY ALL FAILED WITHIN 6 MONTHS OF EACH OTHER. I CHECKED ON YOU TUBE AND FOUND THAT ALMOST ALL BUICK REGALS HAVE THIS PROBLEM OF POWER WINDOW MOTORS BREAKING. THERE ARE HUNDREDS OF COMPLAINTS ON YOU TUBE ALONE FOR THIS ISSUE. I BELIEVE THIS IS PROOF THAT THE POWER WINDOW MOTORS ARE DEFECTIVE AND PROBABLY MADE THIS WAY…

12/01/2020 · Electrical system
THE FIRST TIME THE CAR STALLED WAS AS I WAS APPROACHING THE STOP SIGN.IT STALLED AND THE DASH LIGHT ALL CAME ON. I WAS ABLE TO RE-START IT AFTER PUTTING IT IN PARK. IT THEN HAPPENED AGAIN THE SAME AS BEFORE I GOT HOME. THE NEXT DAY IT DROVE NORMAL FOR AWHILE THEN AS I WAS STARTING IT UP AGAIN IT STARTED WITH A NOISE AND THE LIGHTS ON THE DASH A LIT UP AGAIN…

06/10/2019 · Transmission / drivetrain
FROM A DEAD STOP, WHEN YOU ACCELERATE THE CAR HAS A HARD SHUDDER, TRANS SLIP...BELIEVE IT TO BE A TRANSMISSION PROBLEM AND A PROBLEM GM HAS KNOWN FOR SOMETIME WITH THEIR G4T60-E TRANSMISSION, MOST LIKELY A PRESSURE CONTROL SOLENOID PROBLEM OR CLUTCH ASSEMBLY.

02/25/2019 · Electrical system
POWER WINDOWS ON THIS CAR BURN OUT, 4 MECHANICS SAID THIS IS A VERY COMMON PROBLEM, AND REPAIRS OF THE POWER WINDOWS IS EXPENSIVE

12/18/2018 · Electrical system
TL* THE CONTACT OWNS A 2004 BUICK REGAL. THE CONTACT STATED THAT THE ENGINE WOULD SHUT OFF WHILE THE VEHICLE WAS IN OPERATION. THE VEHICLE WAS ABLE TO RESTART BY USING THE KEY FOB, BUT WOULD SHUT BACK OFF WHEN THE KEY WAS INSERTED IN THE IGNITION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED, BUT A FAILURE WAS NOT FOUND. THE DEALER AND M…

11/15/2018 · Engine · fire
TL* THE CONTACT OWNS A 2004 BUICK REGAL. THE CONTACT STATED THAT THE VEHICLE CAUGHT FIRE WHILE PARKED. THE CONTACT SAW SMOKE ESCAPE FROM UNDERNEATH THE HOOD OF THE VEHICLE AS IT ENTERED INTO THE CABIN OF THE VEHICLE. THE CONTACT'S FRIENDS ATTEMPTED TO EXTINGUISH THE FIRE, BUT WERE UNSUCCESSFUL. THERE WERE NO INJURIES. THE FIRE DEPARTMENT EXTINGUISHED THE FI…

06/22/2018 · Electrical system
TL* THE CONTACT OWNS A 2004 BUICK REGAL. WHILE DRIVING VARIOUS SPEEDS AND WHILE MAKING A LEFT OR RIGHT TURN, THE VEHICLE WOULD INTERMITTENTLY LOSE POWER. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE BY WIGGLING THE KEY IN THE IGNITION SWITCH. THE CONTACT NOTICED THAT THE FAILURE OCCURRED WHEN THE TURN SIGNALS WER…

06/16/2017 · Engine
TL* THE CONTACT OWNS A 2004 BUICK REGAL. THE CONTACT TOOK THE VEHICLE THE DEALER (INTEGRITY DODGE LOCATED ON 6025 INTERNATIONAL DR, CHATTANOOGA, TN) FOR A RECALL REPAIR. THE TECHNICIAN REMOVED THE GRAY COVER GASKET FROM THE ENGINE AND INFORMED THE CONTACT THAT EVERYTHING WAS OK WITH THE ENGINE. THE VEHICLE WAS REPAIRED. IN ADDITION, WHEN THE VEHICLE WAS TAK…