1990 Buick Regal recalls & complaints

Component: FUEL SYSTEM, GASOLINE
Summary: CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence: THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Remedy: HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes: THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

Component: SEAT BELTS
Summary: FRONT SHOULDER SAFETY BELT WEBBING MAY SEPARATE AT FRONT BELT UPPER GUIDE LOOPS ON EITHER SIDE OF THE FRONT SEAT.
Consequence: WEBBING SEPARATION COULD OCCUR WITHOUT PRIOR WARNING ANDINCREASE THE RISK OF INJURY TO BELTED FRONT OUTBOARD OCCUPANTS IN A HIGH ENERGYCRASH.
Remedy: INSTALL A CONTROLLED ROTATION BRACKET ON DRIVER AND PASSENGER SIDE FRONT SEAT BELT GUIDE LOOPS.
Notes: SYSTEM: FRONT SHOULDER SAFETY BELT.VEHICLE DESCRIPTION: PASSENGER CARS.

Component: WHEELS
Summary: CRACKS DEVELOP IN THE WHEEL MOUNTING SURFACE. IF THESE CRACKS BECOME SEVERE ENOUGH, THE WHEEL WILL COMPLETELY SEPARATE FROM THE VEHICLE.
Consequence: IF WHEEL SEPARATION OCCURS WHILE THE VEHICLE IS IN MOTION, LOSS OF STEERING AND BRAKE CONTROL OF THE VEHICLE OCCURS, AND A VEHICLE CRASH COULD RESULT WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL INSPECT THE MANUFACTURING DATE CODES STAMPED ON EACH WHEEL OF THE VEHICLE AND IF A WHEEL FALLS WITHIN THE SPECIFIED DATE CODE RANGE, THE DEALER WILL REPLACE THAT WHEEL ASSEMBLY.
Notes: SYSTEM: WHEELS. VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH KELSEY HAYES STEELWHEELS; MODELS RPO PB9 14" AND PG1 15". NOTE: VEHICLES PREVIOUSLY INSPECTED THAT HAD LESS THAN FOUR WHEELS REPLACED IN RECALL CAMPAIGN 94V-041 ARE TO BE REINSPECTED. NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME, SHOULD CONTACT CHEVROLET AT 1-800-222-1020; BUICK AT 1-800-521-7300; PONTIAC AT 1-800-762-2737; OR OLDSMOBILE AT 1-800-442-6537. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.

Component: WHEELS
Summary: CRACKS DEVELOP IN THE WHEEL MOUNTING SURFACE. IF THESE CRACKS BECOME SEVERE ENOUGH, THE WHEEL WILL COMPLETELY SEPARATE FROM THE VEHICLE.
Consequence: IF WHEEL SEPARATION OCCURS WHILE THE VEHICLE IS IN MOTION, LOSS OF STEERING AND BRAKE CONTROL OF THE VEHICLE OCCURS, AND A VEHICLE CRASH COULD RESULT WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL INSPECT THE MANUFACTURING CODES STAMPED ON EACH WHEEL OF THE VEHICLE AND IF A WHEEL FALLS WITHIN THE SPECIFIED DATE CODE RANGE, THE DEALER WILL REPLACE THAT WHEEL ASSEMBLY.
Notes: SYSTEM: WHEELS. VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH KELSEY HAYES STEEL WHEELS; MODELS RPO PB6 14" AND RPO PG1 15". NOTE: IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND THE REMEDY IS NOT PROVIDED FREE OF CHARGE WITHIN A REASONABLE TIME, PLEASE CONTACT CHEVROLET AT 1-800-222-1020; OLDSMOBILE AT 1-800-442-6537; PONTIAC AT 1-800-762-2737; OR BUICK AT 1-800-521-7300. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.

Component: STRUCTURE
Summary: VEHICLE DESCRIPTION: PASSENGER VEHICLES AND MINI VANS ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: CONNECTICUT, ILLINOIS, INDIANA, MAINE, MASSACHUSETTS, MICHIGAN, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT AND WISCONSIN. THE REAR CRADLE BOLTS PULL THROUGH THE RETAINERS DUE TO CORROSION OF THE RETAINER. IF BOTH BOLTS PULL THROUGH, THE REAR CRADLE WOULD NOT LONGER BE SUPPORTED AT THESE MOUNTING LOCATIONS AND THE STEERING INTERMEDIATE SHAFT CAN SEPARATE FROM THE STEERING GEAR.
Consequence: IF THIS WERE TO OCCUR WHILE THE VEHICLE WAS IN MOTION, A VEHICLE CRASH COULD RESULT.
Remedy: DEALERS WILL REPLACE THE REAR CRADLE BOLTS AND RETAINERS.
Notes: OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING MAY 1997. NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CHEVROLET AT 1-800-222-1020, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.

Component: EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
Summary: BRAKE STOPLAMPS MAY NOT ILLUMINATE OR, IN SOME CASES, STOPLAMPS WILL NOT STAY ILLUMINATED ALL THE TIME WHEN BRAKES ARE APPLIED DUE TO A FAULTY STOPLAMP SWITCH. ALSO IN VEHICLES EQUIPPED WITH CRUISE CONTROL, A FAULTY STOPLAMP SWITCH CAN RESULT IN RESUMPTION OF THE CRUISE CONTROL FUNCTION UPON RELEASE OF THE BRAKE PEDAL.
Consequence: A TRAILING VEHICLE MAY NOT RECOGNIZE A BRAKING ACTIONIN TIME TO RESPOND APPROPRIATELY. ALSO, CRUISE CONTROL WILL REENGAGE UPONRELEASE OF THE BRAKE PEDAL AND RESUME THE SET SPEED. IN EITHER CASE, IT COULDRESULT IN A CRASH WITHOUT PRIOR WARNING.
Remedy: INSTALL AN IMPROVED DESIGN STOPLAMP SWITCH.
Notes: SYSTEM: BRAKE STOPLAMP SWITCH.VEHICLE DESCRIPTION: PASSENGER CARS.NOTE: ALSO SEE NHTSA RECALL 92V086000.

Component: STRUCTURE
Summary: VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, WHERE ROAD SALT USE IS HEAVY. A CONDITION WHERE ONE OR BOTH FRONT ENGINE CRADLE BOLTS CAN PULL THROUGH THE RETAINERS DUE TO CORROSION OF THE RETAINERS.
Consequence: IF BOTH BOLTS PULL THROUGH, THE FRONT OF THE CRADLE WOULD NO LONGER BE SUPPORTED AT THE MOUNTING LOCATIONS AND THE STEERING INTERMEDIATE SHAFT COULD SEPARATE FROM THE STEERING GEAR.
Remedy: DEALERS WILL REPLACE THE FRONT AND REAR FRAME/CRADLE BOLTS AND RETAINERS.
Notes: OWNER NOTIFICATION BEGAN SEPTEMBER 28, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, BUICK AT 1-800-521-7300, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Component: SEAT BELTS:FRONT:WEBBING
Summary: OWNERS MANUALS DID NOT FULLY EXPLAIN HOW FRONT SHOULDER BELT COMFORT FEATURE WORKS.
Consequence: CARS WOULD NOT COMPLY WITH FMVSS 208, AND INCORRECT USE OF SAFETY RESTRAINTS COULD LEAD TO PERSONAL INJURY TO OCCUPANTS IF AN ACCIDENTSHOULD OCCUR.
Remedy: INSERT STICKER THAT PROVIDES MISSING INFORMATION IN OWNERS MANUALS.
Notes: SYSTEM: SAFETY BELTS; FMVSS 208.VEHICLE DESCRIPTION: PASSENGER CARS.

Component: SEAT BELTS
Summary: FRONT SHOULDER BELT GUIDE LOOP ATTACHMENT FASTENER MAY PULL THROUGH DOOR MOUNTED ANCHOR PLATE.
Consequence: SEAT BELT MAY NOT SUSTAIN LOADS REQUIRED BY FMVSS 210, AND IN A VEHICLE ACCIDENT, THE SEAT BELT MAY NOT PROPERLY RESTRAIN A PASSENGER, RESULTING IN INCREASED RISK OF GREATER INJURY TO AN OCCUPANT.
Remedy: REPLACE FRONT SHOULDER BELT GUIDE LOOP ATTACHMENT NUTS AND INSTALL NEW GUIDE COVER.
Notes: SYSTEM: SEAT BELT ANCHORAGE; FMVSS 210. VEHICLE DESCRIPTION: PASSENGER CARS.

09/26/2017 · Electrical system
ELECTRICAL SYSTEMS CONTROLLED BY SIGNAL LEVER DO NOT WORK EXCEPT BY HOLDING LEVER IN CERTAIN POSITIONS: I.E. BRAKE LIGHTS, SIGNAL LEVER L UP, TURN SIGNALS SWITCH LEVER UP, HIGH BEAMS NO GO ETC. ALL THE TIME.

11/15/2007 · Latches / locks · crash
1990 BUICK REGAL HAD EQUIPMENT FAILURE. CONSUMER WAS ABLE TO PULL OVER TO THE SHOULDER UNDER CONTROL WITHOUT ANY PROBLEMS. *KB ACCORDING TO THE POLICE REPORT, UPON INSPECTION OF THE HOOD LATCH AND BRACKET, THE OFFICER DISCOVERED PART OF THE BRACKET AT THE FRONT OF THE ENGINE BAY WAS MISSING. THE BOLT WAS MISSING AS WELL. THE CRASH WAS DUE TO THE HOOD LAT…

09/28/2004 · Body / structure
THE REAR CRADLE BOLTS BROKE AND THE CRADLE SEPARATED FROM THE BODY OF THE VEHICLE. THIS CAUSED THE STEERING LINKAGE COUPLERS TO SEPARATE AND FALL OFF, RESULTING IN LOSS OF STEERING. THIS OCCURRED BECAUSE THE CRADLE BOLTS RUSTED. THIS WOULD NOT HAVE OCCURRED IF CORROSIVE RESTRAINT PARTS WERE USED WHEN THE REAR CRADLE BOLT RECALL 97V058000 REPAIRS WERE P…

02/09/2004 · Wheels / tires
RIGHT FRONT WHEEL VIBRATED. DRIVER PULLED OVER, PULLED OFF LUGS, AND NOTICED THE RIM WAS CRACKED. DEALER WAS CONTACTED. RECALL 94V041000 WAS ISSUED ON THIS MAKE, MODEL, AND YEAR, BUT THIS VEHICLE WAS NOT INCLUDED UNDER RECALL DUE TO VIN. *AK

04/14/2003 · Body / structure
AFTER THE RECALL FOR THE CRADLE BOLTS WAS COMPLETED, THE STEERING FAILED. RECALL #00 V 189 000. *JB AFTER THE RECALL FOR THE CRADLE BOLTS WAS COMPLETED, THE STEERING FAILED. RECALL #00 V 189 000. THERE WAS A CLASS ACTION SUIT ON BRAKES-CONSUMER'S BRAKES FAILED AFTER THE CLASS ACTION SUIT.*MR

11/26/2002 · Body / structure
CONSUMERS SON WAS IN OPERATION OF THE VEHICLE WHEN SUDDENLY ALL STEERING WAS LOST. THE VEHICLE WAS TOWED AND IT WAS EXPLAINED THAT THE FRAME HAD SEPARATED FROM THE CHASSIS AND HAD DROPPED, DISENGAGING THE STEERING ASSEMBLY. THE CAUSE WAS THE CRADLE BOLTS HAD PULLED THROUGH THE RETAINERS DUE TO CORROSION. BUICK SENT CONSUMER A RECALL NOTICE SHORTLY AFTER…

07/09/2002 · Brakes
WHILE APPLYING BRAKES AT 20 MPH BRAKE PEDAL WENT TO THE FLOOR ,AND VEHICLE CONTINUE ON BEFORE STOPPING. DEALER CONTACTED. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION.*AKI

08/29/2001 · Brakes
REAR BRAKE CALIPERS WOULD LOCK UP WHEN BRAKES WERE APPLIED. HAD BRAKES REPLACED TWICE DUE TO PADS WEARING EXCESSIVELY. MECHANIC INDICATED CAUSE OF PROBLEM WAS MASTER CYLINDER.*AK