1998 BMW Z3 Roadster recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-19. Recalls apply to specific VINs — run your VIN to confirm.
1 safety recall, most serious first
1. Lights
What's wrong, in plain English: Headlights, tail lights or turn signals may not work, making the car hard to see. CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
What could happen: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
The fix: PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1998 Z3 ROADSTER.
- Book a repair at any authorized BMW dealer. Quote NHTSA campaign 06E026000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: EXTERIOR LIGHTING
Summary: CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Remedy: PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes: THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES. FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS." CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
Useful for owners
Owner complaints filed with NHTSA
Most complained-about parts: Body / structure (7), Airbags (3), Suspension (2), Transmission / drivetrain (2), Seats (2).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
06/17/2017 · Suspension
A LOUD CLUNKING SOUND COMING FROM REAR END WAS NOTICED. UPON INSPECTION, BY BMW DEALERSHIP IT WAS DETERMINED THE REAR SUBFRAME HOLDING REAR DIFFERENTIAL HAS SEPARATED FROM THE BODY OF THE VEHICLE (SPOT WELD FAILURE). I WAS TOLD IT IS EXTREMELY DANGEROUS TO DRIVE AND TO FIX IMMEDIATELY. UPON FURTHER RESEARCH, THIS APPEARS TO BE A VERY COMMON PROBLEM WITH THE…
02/18/2017 · Body / structure
THE BATTERY COMPARTMENT FILLS WITH WATER WHEN TO RAINS AND DOES NOT EMPTY. THIS PROBLEM ALSO CAUSES RUST AND MOISTURE IN THE TRUNK.
10/16/2011 · Transmission / drivetrain
AT 86K MILES ON MY 1998 BMW Z3, THE THIN SHEET METAL BRACKET HOLDING THE REAR DIFFERENTIAL UP IN PLACE WELDED TO THE CHASSIS SPLIT IN HALF CAUSING THE REAR END TO HANG. THIS IS THE SECOND TIME IT HAS HAPPENED, ALSO AT 93,500 MILES, JUST 8 MONTHS LATER. THE CLUTCH IS STILL ORIGINAL AND THE CAR HAS NEVER BEEN ABUSED, OR RACED. I ALWAYS BABY THE CAR BECAUSE GA…
04/25/2011 · Body / structure
TL* THE CONTACT OWNS A 1998 BMW Z3M ROADSTER. THE CONTACT WAS TRAVELING 25 MPH WHEN THE REAR FRAME OF THE VEHICLE FRACTURED COMPLETELY. THE CONTACT TOWED THE VEHICLE TO THE DEALER WHERE THEY ADVISED THAT THE FRAME METAL WAS EXTREMELY WEAK AND CAUSED THE FRAME TO DROP AND THE REAR AXLE TO FRACTURE FROM THE VEHICLE. THE CONTACT WAS CONCERNED BECAUSE HE COULD…
12/24/2010 · Body / structure
1998 Z3 SUBFRAME FAILURE. I'M WORRIED MY DIFFERENTIAL OR REAR END WILL FAIL DURING DRIVING AND BMW REFUSES TO FIX IT. THIS IS A SAFETY CONCERN FOR EVERYONE ON THE ROAD. BMW HAS INSPECTED MY CAR, ACKNOWLEDGED THE PROBLEM, AND BLAMED THE FAILURE ON THE MODIFICATIONS I MADE TO THE CAR, HOWEVER, THE PROBLEM IS OCCURRING IN A VERY HIGH NUMBER OF UN-MODIFIED Z3 V…
10/13/2010 · Suspension
NORMAL DRIVING RESULTED IN FRAME FAILURE AT THE DIFFERENTIAL MOUNTING POINT. THE ENTIRE DIFFERENTIAL MOUNT BROKE LOOSE FROM THE FRAME AND THE CROSS FRAME IS BROKEN IN TWO PLACES.. THE VEHICLE ALSO HAS TRUNK FLOOR PAN SPOT WELDS BREAKING LOOSE. THE PROBLEMS RESULT IN A REAR AXLE ASSEMBLY THAT IS LOOSE AND STEERS THE CAR ERRATICALLY. THE CAR IS UNSAFE TO DRIV…
07/01/2010 · Transmission / drivetrain
Z3 SUBFRAME PROBLEM. POSSIBLE DETACHMENT OF DIFFERENTIAL FROM CAR. *TR
06/13/2010 · Airbags
THE AIRBAG FAULT LIGHT CAME ON IN OUR 1998 BMW Z3 (WITH LESS THAN 16,000 MILES ON THE ODOMETER), INDICATING THE AIRBAG (OR AIRBAGS) AND SEAT BELT TENSIONERS WERE NO LONGER FUNCTIONING. THE DEALER SERVICE REPRESENTATIVE SAID THIS WAS "A COMMON PROBLEM" WITH THIS MODEL AND TOLD US EXACTLY WHAT MOST LIKELY CAUSE OF THE PROBLEM PRIOR TO ANY DIAGNOSTICS'THAT TH…