2000 BMW K1200rs recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-18. Recalls apply to specific VINs — run your VIN to confirm.
1 safety recall, most serious first
1. Engine
What's wrong, in plain English: Engine problems range from stalling to fire. VEHICLE DESCRIPTION: MOTORCYCLES. A SPRING-LOADED THERMOSTATIC ELEMENT IN THE OIL THERMOSTAT HOUSING IS HELD IN PLACE BY A COVER THAT IS RETAINED BY A SNAP RING. THE SNAP RING MAY NOT HAVE BEEN PROPERLY INSTALLED DURING PRODUCTION. DURING VEHICLE OPERATION, THE SNAP RING COULD UNSEAT, ALLOWING THE COVER TO LOOSEN OR DETACH, RESULTING IN LOSS OF THE ENTIRE OIL VOLUME.
What could happen: ENGINE DAMAGE COULD OCCUR IF THE ENGINE IS NOT IMMEDIATELY SWITCHED OFF. IN ADDITION, OIL COULD TRAVEL ALONG THE ENGINE COVER AND ULTIMATELY CONTACT THE REAR TIRE, REDUCING ITS TRACTION AND AFFECTING THE STABILITY OF THE MOTORCYCLE, POSSIBLY RESULTING IN A CRASH AND PERSONAL INJURY.
The fix: DEALERS WILL INSPECT THE SNAP RING INSTALLATION AND IF THE SNAP RING IS NOT FULLY SEATED, THE COMPLETE OIL PUMP INTERMEDIATE FLANGE WILL BE REPLACED.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2000 K1200RS.
- Book a repair at any authorized BMW dealer. Quote NHTSA campaign 00V264000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: ENGINE AND ENGINE COOLING:ENGINE
Summary: VEHICLE DESCRIPTION: MOTORCYCLES. A SPRING-LOADED THERMOSTATIC ELEMENT IN THE OIL THERMOSTAT HOUSING IS HELD IN PLACE BY A COVER THAT IS RETAINED BY A SNAP RING. THE SNAP RING MAY NOT HAVE BEEN PROPERLY INSTALLED DURING PRODUCTION. DURING VEHICLE OPERATION, THE SNAP RING COULD UNSEAT, ALLOWING THE COVER TO LOOSEN OR DETACH, RESULTING IN LOSS OF THE ENTIRE OIL VOLUME.
Consequence: ENGINE DAMAGE COULD OCCUR IF THE ENGINE IS NOT IMMEDIATELY SWITCHED OFF. IN ADDITION, OIL COULD TRAVEL ALONG THE ENGINE COVER AND ULTIMATELY CONTACT THE REAR TIRE, REDUCING ITS TRACTION AND AFFECTING THE STABILITY OF THE MOTORCYCLE, POSSIBLY RESULTING IN A CRASH AND PERSONAL INJURY.
Remedy: DEALERS WILL INSPECT THE SNAP RING INSTALLATION AND IF THE SNAP RING IS NOT FULLY SEATED, THE COMPLETE OIL PUMP INTERMEDIATE FLANGE WILL BE REPLACED.
Notes: OWNER NOTIFICATION BEGAN OCTOBER 13, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117, OPTION #5. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
Useful for owners
Owner complaints filed with NHTSA
Most complained-about parts: Fuel system (1), Gasoline (1), Brakes (1), Hydraulic (1), Suspension (1).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (4)
11/27/2010 · Fuel system
WHILE RIDING ON EXPRESSWAY ENGINE QUIT AND I PULLED TO THE SIDE OF THE ROAD. FUEL WAS BEING PUMPED OUT ONTO THE HOT ENGINE AND MY SHOES AND CLOTHING. ON INSPECTION FOUND A BROKEN FUEL LINE CONNECTOR ON THE HIGH PRESSURE SIDE OF THE FUEL LINE GOING FROM THE FUEL PUMP TO THE FUEL INJECTION SYSTEM ON THE MOTOR. AT A LATER DATE THE LOW PRESSURE SIDE OF THE S…
08/26/2007 · Brakes
THE MOTORCYCLE EXPERIENCED AN ABS FAULT WARNING WHILE RIDING ON HIGHWAY. NO LOSS OF CONTROL OR DAMAGE BUT THE PARTIALLY LINKED ABS BRAKES NO LONGER WORKED. THE DEALER WAS ABLE TO DIAGNOSE THE FAULT CODE AS "FAULTY HYDRAULIC PRESSURE MODULATOR PUMP" THE DEALER RESET THE ALARM CODE AND THE ABS SYSTEM OPERATED FOR ABOUT 300 MILES WHEN IT FAULTED. A SECOND…
05/31/2007 · Suspension
1) I HIT 2 POTHOLES IN THE ROAD, ONE RIGHT AFTER THE OTHER. 2) THE FRONT WHEEL FENDER GOT LODGED BETWEEN THE RADIATOR AND THE FAIRING. 3) TOOK BIKE TO THE DEALER WHERE THEY APPARENTLY COMPRESSED THE SHOCKS ALL THE WAY TO PULL THE FENDER OUT. NO PARTS WERE REPLACED. DEALER REPORTED ALL PARTS IN GOOD CONDITION. *TR
08/18/2002 · Transmission / drivetrain
DIFFERENTIAL CROWN WHEEL BEARING FAILED TWICE. FIRST FAILURE 8/21/01 @ 47200 MILES SECOND FAILURE ON 8/15/02 @ 73800 MILES. THERE WAS NO WARNING ON FIRST FAILURE OTHER THAN THE SMELL OF REAR DIFF. LUBE. SECOND FAIURE OCCURED AT FREEWAY SPEED AND ALMOST CAUSED LOSS OF CONTROL OF MOTORCYCLE. MANUFACTURER COVERED EXPENSE OF FIRST FAILURE. WAITING FOR AN A…