2016 BMW 5 Series recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-18. Recalls apply to specific VINs — run your VIN to confirm.
Recalls: check by VIN
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- 2016 BMW 5 Series owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Engine (49), Electrical system (33), Airbags (12), Fuel system (9), Unknown Or Other (8).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
07/29/2026 · Fuel system
Vehicle: 2016 BMW 528i xDrive (VIN: [XXX]) Safety Issue / Defect Description: Strong, hazardous raw gasoline fumes began entering the passenger cabin and trunk area. On XXX, the vehicle was brought to an authorized dealership (BMW of Sterling) for diagnostic evaluation. The dealership's technician conducted a multi-point inspection and produced video evid…
07/20/2026 · Fuel system
The vehicle developed a strong, toxic odor of raw gasoline inside the passenger cabin and trunk area. The vehicle was brought to an authorized franchise, BMW of Sterling, where technicians performed a multi-point inspection. The technician confirmed that the factory plastic fuel tank assembly is structurally defective and leaking raw fuel from the top weld…
02/23/2026 · Engine
The contact owns a 2016 BMW 528i. The contact stated that the vehicle was repaired under an unknown recall, and after the recall repair, while driving at an undisclosed speed, there was an abnormal oil-burning odor entering the cabin of the vehicle. The vehicle was taken to a local Midas, where it was discovered that oil was leaking onto the engine. The veh…
02/09/2026 · Lights
I have 2016 BMW 5 series car, for past two to three years headlights are getting condensation inside on colder months. Dealer is not able to fix the condensation, they are advising to replace the headlights. Some of my friends replaced OEM headlights, but after few years they are started condensation, it’s looked like defect from manufacturer, I had few Hon…
01/27/2026 · Electrical system · fire
On January 29, 2020, while driving my 2016 BMW 5 Series under normal operating conditions, the engine compartment caught fire without warning. Smoke and flames originated from the engine bay while the vehicle was in motion. I was forced to pull over and exit the vehicle immediately. The fire spread rapidly, and the vehicle was declared a total loss. At the…
11/02/2025 · Electrical system · fire
My coolant line overheated. From the leaking water pump and pcv that exploded all over my engine causing it to overheat and now how has not turned back on. Ive been without a car for months and when I seen the recall and reached out to the dealer expressing my situation they said they would get back to me and have not called or emailed or even responded in…
09/12/2025 · Engine
During initial cold starts there is blue smoke billowing from the exhaust for approx 20 seconds. The odor is horrible.
08/27/2025 · Transmission / drivetrain
A critical component failure has rendered my 2016 BMW 528xi inoperable and unsafe. The water pump failed, forcing the car into a safety "limp mode," limiting its speed to approximately 40 miles per hour. This issue mirrors NHTSA Recall 24V-608 regarding an electrical connector on the water pump that can short circuit, potentially causing a "thermal event or…