1992 BMW 325i recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-19. Recalls apply to specific VINs — run your VIN to confirm.
4 safety recalls, most serious first
1. Vehicle Speed Control
What's wrong, in plain English: A vehicle part that may fail. THE CRUISE CONTROL AND THROTTLE CABLES ARE ATTACHED TO THE SAME THROTTLE VALVE ACTUATING LEVER AT THE THROTTLE HOUSING. IT IS POSSIBLE THAT THE PLASTIC BUSHING ON EITHER CABLE COULD BREAK DUE TO ENVIRONMENTAL INFLUENCES COUPLED WITH VIBRATION. IF THE BUSHING BREAKS, THE OUTER CABLE HOUSING CAN SEPARATE FROM THE BUSHING. IN THIS CASE, DURING APPLICATION OF THE THROTTLE PEDAL WITHOUT CRUISE CONTROL BEING ENGAGED, THE…
What could happen: THIS COULD CAUSE THE THROTTLE VALVE TO REMAIN PARTIALLY OPEN. IT HIS WERE TO OCCUR, THE CAR MIGHT NOT DECELERATE AS EXPECTED INCREASING THE RISK OF A VEHICLE CRASH.
The fix: DEALERS WILL INSTALL A SPRING STEEL CLIP ON THE OUTER TUBE OF EACH CABLE IN THE AREA OF THE ADJUSTING SCREW AND PLASTIC BUSHING. THE CLIP IS DESIGNED TO PREVENT THE OUTER TUBE FROM DISLODGING FROM THE BUSHING.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1992 325I.
- Book a repair at any authorized BMW dealer. Quote NHTSA campaign 97V131000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: VEHICLE SPEED CONTROL
Summary: THE CRUISE CONTROL AND THROTTLE CABLES ARE ATTACHED TO THE SAME THROTTLE VALVE ACTUATING LEVER AT THE THROTTLE HOUSING. IT IS POSSIBLE THAT THE PLASTIC BUSHING ON EITHER CABLE COULD BREAK DUE TO ENVIRONMENTAL INFLUENCES COUPLED WITH VIBRATION. IF THE BUSHING BREAKS, THE OUTER CABLE HOUSING CAN SEPARATE FROM THE BUSHING. IN THIS CASE, DURING APPLICATION OF THE THROTTLE PEDAL WITHOUT CRUISE CONTROL BEING ENGAGED, THE OUTER TUBE COULD CATCH ON THE EDGE OF THE BROKEN BUSHING.
Consequence: THIS COULD CAUSE THE THROTTLE VALVE TO REMAIN PARTIALLY OPEN. IT HIS WERE TO OCCUR, THE CAR MIGHT NOT DECELERATE AS EXPECTED INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSTALL A SPRING STEEL CLIP ON THE OUTER TUBE OF EACH CABLE IN THE AREA OF THE ADJUSTING SCREW AND PLASTIC BUSHING. THE CLIP IS DESIGNED TO PREVENT THE OUTER TUBE FROM DISLODGING FROM THE BUSHING.
Notes: OWNER NOTIFICATION IS EXPECTED TO BEGIN BY THE END OF OCTOBER 1997. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
2. Airbags
What's wrong, in plain English: The airbag system — the part that is supposed to protect you in a crash. THE AIR BAG CONTACT RING LOCKING TAB LOCATED IN THE STEERING WHEEL ASSEMBLY CAN BREAK WITHOUT WARNING.
What could happen: IF THIS HAPPENS, THE CONTACT RING WIRING COULD EVENTUALLY BREAK. THE AIR BAG READINESS INDICATOR LAMP (SRS OR AIRBAG) IN THE INSTRUMENT CLUSTER WILL ILLUMINATE, AND THE AIR BAG WOULD NOT DEPLOY IN THE EVENT OF A FRONTAL IMPACT VEHICLE COLLISION.
The fix: DEALERS WILL REPLACE THE LOCKING TAB WITH ONE OF A DIFFERENT DESIGN.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1992 325I.
- Book a repair at any authorized BMW dealer. Quote NHTSA campaign 96V110000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: AIR BAGS:FRONTAL
Summary: THE AIR BAG CONTACT RING LOCKING TAB LOCATED IN THE STEERING WHEEL ASSEMBLY CAN BREAK WITHOUT WARNING.
Consequence: IF THIS HAPPENS, THE CONTACT RING WIRING COULD EVENTUALLY BREAK. THE AIR BAG READINESS INDICATOR LAMP (SRS OR AIRBAG) IN THE INSTRUMENT CLUSTER WILL ILLUMINATE, AND THE AIR BAG WOULD NOT DEPLOY IN THE EVENT OF A FRONTAL IMPACT VEHICLE COLLISION.
Remedy: DEALERS WILL REPLACE THE LOCKING TAB WITH ONE OF A DIFFERENT DESIGN.
Notes: SYSTEM: INTERIOR; PASSIVE RESTRAINT; AIR BAG; DRIVER. VEHICLE DESCRIPTION: PASSENGER VEHICLES. OWNER NOTIFICATION: OWNER NOTIFICATION IS EXPECTED TO BEGIN AUGUST 5, 1996. NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
3. Brakes
What's wrong, in plain English: Anything that slows the car down. Treat brake recalls as urgent. THE BRAKE LIGHT SWITCH CAN FAIL ALLOWING THE SWITCH TO REMAIN IN THE "BRAKE LIGHTS OFF" POSITION OR IN THE "BRAKE LIGHTS ON" POSITION.
What could happen: IF THIS HAPPENS, THE BRAKE LIGHTS EITHER WILL NOT OPERATE OR WILL BE CONTINUOUSLY ON, REGARDLESS OF BRAKE PEDAL POSITION. FOLLOWING DRIVERS WOULD NOT BE ABLE TO DETERMINE WHETHER THE VEHICLE IS STOPPING, INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
The fix: DEALERS WILL REPLACE THE EXISTING BRAKE LIGHT SWITCH WITH A NEWLY DESIGNED SWITCH.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1992 325I.
- Book a repair at any authorized BMW dealer. Quote NHTSA campaign 96V111000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
Summary: THE BRAKE LIGHT SWITCH CAN FAIL ALLOWING THE SWITCH TO REMAIN IN THE "BRAKE LIGHTS OFF" POSITION OR IN THE "BRAKE LIGHTS ON" POSITION.
Consequence: IF THIS HAPPENS, THE BRAKE LIGHTS EITHER WILL NOT OPERATE OR WILL BE CONTINUOUSLY ON, REGARDLESS OF BRAKE PEDAL POSITION. FOLLOWING DRIVERS WOULD NOT BE ABLE TO DETERMINE WHETHER THE VEHICLE IS STOPPING, INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL REPLACE THE EXISTING BRAKE LIGHT SWITCH WITH A NEWLY DESIGNED SWITCH.
Notes: SYSTEM: BRAKES; HYDRAULIC; SWITCH; BRAKE LIGHT. VEHICLE DESCRIPTION: PASSENGER VEHICLES. OWNER NOTIFICATION: OWNER NOTIFICATION IS EXPECTED TO BEGIN AUGUST 5, 1996. NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
4. Engine
What's wrong, in plain English: Engine problems range from stalling to fire. VEHICLE DESCRIPTION: PASSENGER VEHICLES. A MALFUNCTION OR FAILURE OF A COOLANT SYSTEM COMPONENT, SUCH AS A THERMOSTAT, WATER PUMP, OR FAN BELT, CAN RESULT IN SIGNIFICANTLY INCREASED COOLANT TEMPERATURE AND SYSTEM PRESSURE. IF THE INDICATIONS OF A CRITICAL OVERHEATING CONDITION IS NOT NOTICED BY THE DRIVER, IT IS POSSIBLE THAT DAMAGE TO, OR FAILURE OF, A COOLANT SYSTEM COMPONENT COULD OCCUR.
What could happen: IF A CRACK WERE TO FORM OR A SEAM WERE TO SEPARATE IN THE HEATER CORE END PIECE, HOT COOLANT COULD SUDDENLY BE EXPELLED, INCREASING THE RISK OF PERSONAL INJURY TO A VEHICLE OCCUPANT.
The fix: DEALERS WILL INSTALL A NEW DESIGN RADIATOR CAP TO CONTROL PRESSURE AND PROVIDE GREATER COOLANT OVERFLOW IN THE EVENT OF OVERHEATING.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 1992 325I.
- Book a repair at any authorized BMW dealer. Quote NHTSA campaign 98V178000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: ENGINE AND ENGINE COOLING:COOLING SYSTEM
Summary: VEHICLE DESCRIPTION: PASSENGER VEHICLES. A MALFUNCTION OR FAILURE OF A COOLANT SYSTEM COMPONENT, SUCH AS A THERMOSTAT, WATER PUMP, OR FAN BELT, CAN RESULT IN SIGNIFICANTLY INCREASED COOLANT TEMPERATURE AND SYSTEM PRESSURE. IF THE INDICATIONS OF A CRITICAL OVERHEATING CONDITION IS NOT NOTICED BY THE DRIVER, IT IS POSSIBLE THAT DAMAGE TO, OR FAILURE OF, A COOLANT SYSTEM COMPONENT COULD OCCUR.
Consequence: IF A CRACK WERE TO FORM OR A SEAM WERE TO SEPARATE IN THE HEATER CORE END PIECE, HOT COOLANT COULD SUDDENLY BE EXPELLED, INCREASING THE RISK OF PERSONAL INJURY TO A VEHICLE OCCUPANT.
Remedy: DEALERS WILL INSTALL A NEW DESIGN RADIATOR CAP TO CONTROL PRESSURE AND PROVIDE GREATER COOLANT OVERFLOW IN THE EVENT OF OVERHEATING.
Notes: OWNER NOTIFICATION BEGAN MARCH 31, 1999. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- 1992 BMW 325i owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Engine (18), Body / structure (11), Electrical system (8), Visibility (wipers / glass) (8), Fuel system (7).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
04/21/2014 · Wheels / tires
I WAS DRIVING AT 70MPH ON I71 WITH CRUISE CONTROL ENABLED WHEN I FELT VIBRATIONS FOR APPROX. 20 SECONDS AND THEN MY RIGHT REAR TIRE BLEW OUT. I HAD DRIVEN APPROXIMATELY 30 MILES UP TO THIS POINT AND I VERIFIED THAT TIRE TO BE 36 PSI AS RECENTLY AS THAT MORNING. THE TIRE HAS NO PUNCTURE DAMAGE AND THE BEAD IS STILL FULLY SET ON BOTH SIDES. THE TIRE SEPARATED…
11/26/2008 · Transmission / drivetrain
TL*THE CONTACT OWNS A 1992 BMW 325. WHILE DRIVING 60 MPH, THE VEHICLE BEGAN TO BACKFIRE AND LOSE POWER. THE MECHANIC COULD NOT DETERMINE THE CAUSE OF THE FAILURE. THE VEHICLE WOULD ALSO HESITATE AND SHAKE WHEN IT WAS INITIALLY STARTED. THE VIN WAS UNKNOWN. THE CURRENT MILEAGE WAS 206,000 AND FAILURE MILEAGE WAS 198,880.
08/18/2008 · Latches / locks
TL*THE CONTACT OWNS A 1992 BMW 325I. WHENEVER THE CONTACT LOCKS THE DOORS FROM THE OUTSIDE OF THE VEHICLE, HE IS UNABLE TO UNLOCK THEM FROM INSIDE THE PASSENGER COMPARTMENT. ONCE HE LOCKS THE DOORS, THE DOOR HANDLES AND LOCKS FAIL INSIDE THE PASSENGER COMPARTMENT. THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALER. THE CURRENT AND FAILURE MILEAGES WERE 20…
08/17/2008 · Latches / locks
I LOCKED MY 1992 BMW 325I WITH THE KEY FROM THE OUTSIDE WITH MY FRIEND INSIDE (I DID NOT REALIZE HE HAD NOT GOTTEN OUT OF THE VEHICLE YET). I HAD DROPPED THE KEY WHEN I HEARD HIM POUND ON THE WINDOW (LOOSING THE KEY IN SOME BRUSH). WHEN THIS SITUATION HAD TRANSPIRED I FOUND OUT THAT HE COULD NOT OPEN ANY OF THE DOORS FROM INSIDE OF THE VEHICLE IN ANY MANNER…
05/21/2006 · Body / structure
1992 BMW 325IS. REAR SUBFRAME MOUNT FAILURE. LOOSE REAR END. CLUNKING NOISES. TORN UNDER BELLY WHERE REAR SUBFRAME BOLTS TO UNIBODY OF CAR. *JB
07/27/2005 · Wheels / tires
THIS JUNE OF 2005 WHILE MY 92BMW325I WAS PARKED AT THE MALL, THE BACK PASSENGER TIRE I NOTICED BLEW UP. WHEN I BROUGHT IT TO PIT STOP TO HAVE THE TIRE VULCANIZED, THEY SAID THEY CAN'T DO ANYTHING W/IT BUT BE REPLACED. I REPLACED IT AT SAM'S CLUB W/AP205/60R15H TOUR. I ASKED IF THE OTHER 3 TIRES NEED TO BE REPLACED & THEY SAID "NO". LAST SUNDAY JUL 24 WHILE…
01/14/2005 · Body / structure
WHILE ENTERING INTO THE VEHICLE THE DOOR FAILED TO OPENED. THE LEFT AND RIGHT SIDE DOOR WAS UNABLE TO OPEN PROPERLY. THE DRIVER WAS ABLE TO CONTACT THE DEALER FOR APPOINTMENT. PLEASE PROVIDE ADDITIONAL INFORMATION. *JB
11/17/2004 · Body / structure
1) MOUNTS FOR REAR SUBFRAME TO BODY NOT STRONG ENOUGH. THEY FLEX AND CRACK LEADING TO A CHAIN REACTION THEN THE REAR END RIPS OFF. 2)I WAS DRIVING DOWN A BUSY TWO WAY ROAD. THEN ALL OF A SUDDEN MY CARS REAR END IS MOVING TO THE LEFT AND I LOST CONTROL FOR A LITTLE. LUCKILY DIDNT CRASH INTO ANOTHER CAR. THEN I REGAINED CONTROL AND DROVE BACK TO MY HOUSE WHI…