2005 Audi Tt recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-18. Recalls apply to specific VINs — run your VIN to confirm.
1 safety recall, most serious first
1. Engine
What's wrong, in plain English: Engine problems range from stalling to fire. The Gates Corporation (Gates) is recalling certain aftermarket Tru-Flow Water Pumps, part number TFW 41127, sold at certain NAPA Auto Parts and/or installed by automotive service technicians after November 1, 2013 (and manufactured August 2013 through October 2013) that have a black-colored pulley/sprocket or do not have 'US9377' stamped on the water pump housing. These service replacement parts were sold for use in…
What could happen: A failure of the timing belt may cause the engine to shut down, potentially increasing the risk of a vehicle crash.
The fix: Gates will notify owners, and dealers will replace the water pump, free of charge. The recall began during May 2014. Owners may contact The Gates Corporation at 1-303-744-1911.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2005 TT.
- Book a repair at any authorized Audi dealer. Quote NHTSA campaign 14E007000.
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-303-744-1911.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: ENGINE AND ENGINE COOLING:ENGINE
Summary: The Gates Corporation (Gates) is recalling certain aftermarket Tru-Flow Water Pumps, part number TFW 41127, sold at certain NAPA Auto Parts and/or installed by automotive service technicians after November 1, 2013 (and manufactured August 2013 through October 2013) that have a black-colored pulley/sprocket or do not have 'US9377' stamped on the water pump housing. These service replacement parts were sold for use in model year 1999-2005 Audi A4, 2000-2006 Audi TT, 1998-2005 Volkswagen Beetle, 1999-2006 Golf, 1999-2008 and 2011-2013 Volkswagen Jetta, and 2000-2005 Volkswagen Passat. In the affected water pumps, the pulley or sprocket that turns the timing belt may develop microfractures causing the timing belt to fail.
Consequence: A failure of the timing belt may cause the engine to shut down, potentially increasing the risk of a vehicle crash.
Remedy: Gates will notify owners, and dealers will replace the water pump, free of charge. The recall began during May 2014. Owners may contact The Gates Corporation at 1-303-744-1911.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Useful for owners
Owner complaints filed with NHTSA
Most complained-about parts: Electrical system (3), Airbags (3), Engine (3), Lights (3), Transmission / drivetrain (3).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
04/16/2016 · Electrical system
THE TRUNK RELEASE BUTTON DOES NOT ALWAYS WORK. THE DRIVER'S WINDOW SOMETIMES DOES NOT CLOSE UP WHEN DOOR IS CLOSED THEREBY CAUSING THE DASHBOARD TO SHOW THAT THE DOOR IS OPEN AND BEEPING OCCURS. I ALSO HAD TO HAVE THE RELEASE FOR THE GAS CAP DISCONNECTED DUE TO NOT BEING ABLE TO RELEASE GAS CAP.
04/04/2016 · Airbags
TL* THE CONTACT OWNS A 2005 AUDI TT. WHILE DRIVING 25 MPH, THE VEHICLE FAILED TO ACCELERATE WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. THE AIR BAG AND CHECK ENGINE WARNING LIGHTS ILLUMINATED. THE FAILURE OCCURRED CONSTANTLY. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 75,000. ..UPDAT…
11/23/2015 · Lights
DRIVER'S SIDE HEADLIGHT TURNS OFF INTERMITTENTLY WHILE VEHICLE IS IN MOTION. TURNING THE HEADLIGHTS OFF AND THEN ON AGAIN, BRINGS BOTH HEADLIGHTS BACK TO OPERATIONAL.
11/08/2013 · Electrical system
THE PASSENGER SIDE HEAD LAMP FLICKERS AND TURNS OFF WHILE DRIVING. THE HEAD LIGHTS MUST BE TURNED OFF AND BACK ON TO TEMPORARILY CORRECT THE ISSUE. THIS HAPPENS MULTIPLE TIMES A DAY. *TR
04/15/2013 · Transmission / drivetrain
WHILE DRIVING DOWN THE FREEWAY THE TRANSMISSION SHIFTED TO NEUTRAL AND THE CAR WOULD NOT GO BACK INTO DRIVE. FORTUNATELY THE TRAFFIC WAS NOT HEAVY AT THIS TIME AND I WAS ABLE TO PULL OFF THE ROAD WITHOUT AN ACCIDENT. THE NEUTRAL PROBLEM NOW OCCURS QUITE OFTEN AND I NOW HAVE THE CAR IN FOR REPAIR. THE TRANSMISSION IS A DSG AUTOMATIC TRANSMISSION AND AFTER…
05/03/2012 · Transmission / drivetrain
TL* THE CONTACT OWNS A 2005 AUDI TT ROADSTER. THE CONTACT STATED THAT THE TRANSMISSION FLUID WAS LEAKING. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE TRANSMISSION HAD BEEN PUNCTURED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 30,489 AND THE CURRENT MILEAGE WAS 30,495.
04/17/2012 · Transmission / drivetrain
WHILE STARTING OFF IT JERKS AND THE PRNDS FLASH. I LOOKED ALL OVER THE NET. AND IT'S A GEARBOX PROBLEM. AUDI WANTS 9500 CANADIAN TO FIX A 17000 CAR. THERE ARE LOTS OF LINKS UNDER DSG GEARBOX. I TALKED TO AUDI THEY SAY IT'S NOT A PROBLEM AND THERE IS NO RECALL. I LIVE IN CANADA. *JS
03/14/2011 · Airbags
AIR BAG LIGHT CONTINUES TO COME ON. THIS APPEARS TO BE SIMILAR TO OTHER COMPLAINTS AROUND THE CONNECTOR. THIS HAPPENS WHEN THE SEAT IS MOVED FORWARD OR BACKWARD TO ACCOMMODATE DIFFERENT SIZE DRIVERS. REPLACEMENT OF THE AIR BAG DID NOT SOLVE THIS ISSUE. *TR