2011 Audi Q7 recalls & complaints
Source: NHTSA, updated daily. Last checked 2026-10-18. Recalls apply to specific VINs — run your VIN to confirm.
4 safety recalls, most serious first
1. Fuel system
What's wrong, in plain English: Fuel lines, tank or pump. Fuel problems usually mean a leak, and leaks mean fire risk. Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2007-2012 Audi Q7 and 2009-2012 Audi Q5 vehicles, previously repaired under NHTSA recall 16V-660. These vehicles were previously repaired with an interim repair of installing butyl tape to the fuel pump flange, until replacement remedy parts became available.
What could happen: The butyl tape may not prevent fuel from leaking. A fuel leak in the presence of an ignition source can increase the risk of a fire.
The fix: Volkswagen will notify owners, and dealers will replace the fuel pump flange and install butyl tape, free of charge. The recall began December 28, 2018. Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 20BJ.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2011 Q7.
- Book a repair at any authorized Audi dealer. Quote NHTSA campaign 18V818000 (manufacturer code 20BJ).
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-253-2834.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
Summary: Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2007-2012 Audi Q7 and 2009-2012 Audi Q5 vehicles, previously repaired under NHTSA recall 16V-660. These vehicles were previously repaired with an interim repair of installing butyl tape to the fuel pump flange, until replacement remedy parts became available.
Consequence: The butyl tape may not prevent fuel from leaking. A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Volkswagen will notify owners, and dealers will replace the fuel pump flange and install butyl tape, free of charge. The recall began December 28, 2018. Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 20BJ.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
2. Fuel system
What's wrong, in plain English: Fuel lines, tank or pump. Fuel problems usually mean a leak, and leaks mean fire risk. Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2012 Audi Q5, and 2007-2012 Audi Q7 vehicles equipped with gasoline engines. The fuel pump flange on the affected vehicles may crack, allowing fuel to leak.
What could happen: A fuel leak in the presence of an ignition source increases the risk of a fire.
The fix: Audi will notify owners, and dealers will inspect the flange, replacing any flanges that are cracked. If the flange is not cracked, dealers will clean the pump flange and install a butyl rubber band to protect the pump. These repairs will be made free of charge. The recall began November 9, 2016. Owners may contact…
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2011 Q7.
- Book a repair at any authorized Audi dealer. Quote NHTSA campaign 16V660000 (manufacturer code 20W9).
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-253-2834.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
Summary: Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2012 Audi Q5, and 2007-2012 Audi Q7 vehicles equipped with gasoline engines. The fuel pump flange on the affected vehicles may crack, allowing fuel to leak.
Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Audi will notify owners, and dealers will inspect the flange, replacing any flanges that are cracked. If the flange is not cracked, dealers will clean the pump flange and install a butyl rubber band to protect the pump. These repairs will be made free of charge. The recall began November 9, 2016. Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 20W9.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
3. Fuel system
What's wrong, in plain English: Fuel lines, tank or pump. Fuel problems usually mean a leak, and leaks mean fire risk. In the affected vehicles the fuel injection system may experience a fuel leak.
What could happen: A fuel leak in the injection system in the presence of an ignition source, increases the risk of a fire.
The fix: Volkswagen will notify owners, and dealers will replace the fuel rails and corresponding seals, free of charge. The recall began on March 17, 2015. Owners may contact Audi customer service at 1-800-822-2834 or Volkswagen customer service at 1-800-893-5298. Volkswagen's numbers for this recall are 24AP for Audi custo…
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2011 Q7.
- Book a repair at any authorized Audi dealer. Quote NHTSA campaign 15V019000 (manufacturer code 24AP for Audi customers and 24BK for Volkswagen customers).
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-822-2834.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:FUEL RAIL
Summary: Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2011-2012 Audi S4, S5, Q7, 2012 Audi A6, Volkswagen Touareg Hybrid, and 2012-2013 Audi A7 vehicles. In the affected vehicles the fuel injection system may experience a fuel leak.
Consequence: A fuel leak in the injection system in the presence of an ignition source, increases the risk of a fire.
Remedy: Volkswagen will notify owners, and dealers will replace the fuel rails and corresponding seals, free of charge. The recall began on March 17, 2015. Owners may contact Audi customer service at 1-800-822-2834 or Volkswagen customer service at 1-800-893-5298. Volkswagen's numbers for this recall are 24AP for Audi customers and 24BK for Volkswagen customers.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
4. Equipment
What's wrong, in plain English: A part or accessory supplied with the vehicle. The Gross Axle Weight Rating (GAWR) listed on the certification label is incorrect, which can allow the vehicle to be overloaded. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims," and Part 567, "Certification."
What could happen: An overloaded vehicle can increase the risk of a crash.
The fix: Dealers will install an overlay label containing the correct rear GAWR on top of the existing safety certification label, free of charge. Owner notification letters were mailed April 24, 2023. Owners may contact Audi's customer service at 1-800-253-2834. Audi's number for this recall is 50G5.
What to do
- Check whether your car is affected: enter your 17-digit VIN at nhtsa.gov/recalls. A recall covers specific VINs, not every 2011 Q7.
- Book a repair at any authorized Audi dealer. Quote NHTSA campaign 23V086000 (manufacturer code 50G5).
- The repair is free. By US law, safety recall repairs cost the owner nothing, no matter the car's age or mileage.
- Manufacturer hotline: 1-800-253-2834.
- Buying this car used? Ask the seller for proof the recall was completed, or run the VIN yourself before paying.
Official wording from NHTSA
Component: EQUIPMENT:OTHER:LABELS
Summary: Volkswagen Group of America, Inc. (Audi) is recalling certain 2009-2015 Q7 vehicles. The Gross Axle Weight Rating (GAWR) listed on the certification label is incorrect, which can allow the vehicle to be overloaded. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims," and Part 567, "Certification."
Consequence: An overloaded vehicle can increase the risk of a crash.
Remedy: Dealers will install an overlay label containing the correct rear GAWR on top of the existing safety certification label, free of charge. Owner notification letters were mailed April 24, 2023. Owners may contact Audi's customer service at 1-800-253-2834. Audi's number for this recall is 50G5.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Useful for owners
- OBD2 code reader — see what the car's computer is reporting
- Compact car fire extinguisher
- 2011 Audi Q7 owner's manual
Owner complaints filed with NHTSA
Most complained-about parts: Visibility (wipers / glass) (7), Fuel system (5), Unknown Or Other (4), Electrical system (2), Engine (2).
Complaints are unverified reports from owners. A pattern (many complaints about the same part) matters more than any single one.
Read recent complaints (8)
09/10/2025 · Unknown Or Other
Driving on a country road with no vehicle in front of me - a loud explosion occurred and realized the front panel of the sunroof had exploded. Luckily, the screen was closed at the time and no large glass fragments fell into the occupants of the vehicle - there were five of us at the time. Arrived at a friend’s house to vacuum out the small slivers of glass…
10/18/2024 · Fuel system
The Bosch CP4 High Pressure Fuel Pump failed suddenly at interstate speed (65-70mph) as I was driving up a hill in 3 lanes of traffic. The car stalled immediately and lost all motive power. I had to limp across 3 lanes of traffic to get to the shoulder right away, risking collision from passing vehicles. I could provide the damaged pump for inspection if…
09/01/2024 · Fuel system
The smell of gasoline out side on the left and the right behind driver seat. Please help me. I searched on YouTube alot of car audi brand recall to fix the issue. They said cracked and leaked the cap of filter fuel pump.
10/13/2023 · Visibility (wipers / glass)
Passenger windshield wiper snapped off. Light rain and also driving at normal interstate speed.
08/21/2023 · Visibility (wipers / glass)
Driving on a Saturday evening when it started raining. Wipers automatically engaged, suddenly saw passenger side blade warp then snap off and fly off the to the side of the street causing the driver behind me to swerve almost causing an accident. I pulled over immediately, to retrieve the piece to try and determine what happened. Saw that it just snapped of…
07/07/2023 · Fuel system
The contact owns a 2011 Audi Q7. The contact stated while driving 45 MPH, the vehicle lost motive power and stalled without warning. The contact was unable to restart the vehicle and had the vehicle towed to an independent mechanic to be diagnosed. The independent mechanic stated that the high-pressure fuel pump had failed. The contact was informed that the…
11/20/2022 · Visibility (wipers / glass)
2 separate occasions now, the passenger-side windshield wipers have broken off. This is apparently a common incident with some Audi vehicles due to poor manufacturing/design. Audi has not implemented a recall. This is a safety concern as the wipers have broken off while I was driving and could hit another vehicle!
11/22/2020 · Visibility (wipers / glass)
I WAS DRIVING IN THE RAIN WITH MY WIPERS ON, SET ON LOW WHEN THE PASSENGER SIDE WIPER EJECTED ITSELF AND THE WIPER ARM BROKE NEAR THE BASE. TO KEEP MY WINDSHIELD FROM BEING SCRATCHED I HAD TO TURN MY WIPERS OFF ALTOGETHER FORCING ME TO DRIVE IN THE UNSAFE CONDITION OF POOR VISIBILITY. THERE WERE NO SIGNS THAT THE ARM WAS ABOUT TO BREAK OR THE WIPER WAS ABOU…