1999 Audi A4 recalls & complaints

Component: AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE
Summary: Volkswagen Group of America, Inc. (VW) is recalling certain 2000-2001 TT Roadster, 2000 TT Coupe, 1999 Audi A8, 1998-2000 Audi A6, and 1999-2000 Audi A4 vehicles equipped with Non-Azide Driver air bag Inflators (NADI) that do not contain phase stabilized ammonium nitrate (PSAN) propellant. Due to a manufacturing issue, the NADI inflators may absorb moisture, possibly causing the air bag to deploy improperly in the event of a crash.
Consequence: In the event of a crash necessitating air bag deployment, the air bag may not properly protect the occupant, increasing the risk of serious injury or death.
Remedy: Dealers will replace the driver frontal air bag inflator with an alternative inflator when the parts become available, free of charge. Owner notifications were mailed September 21, 2021. Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 69BT.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Component: ENGINE AND ENGINE COOLING:ENGINE
Summary: The Gates Corporation (Gates) is recalling certain aftermarket Tru-Flow Water Pumps, part number TFW 41127, sold at certain NAPA Auto Parts and/or installed by automotive service technicians after November 1, 2013 (and manufactured August 2013 through October 2013) that have a black-colored pulley/sprocket or do not have 'US9377' stamped on the water pump housing. These service replacement parts were sold for use in model year 1999-2005 Audi A4, 2000-2006 Audi TT, 1998-2005 Volkswagen Beetle, 1999-2006 Golf, 1999-2008 and 2011-2013 Volkswagen Jetta, and 2000-2005 Volkswagen Passat. In the affected water pumps, the pulley or sprocket that turns the timing belt may develop microfractures causing the timing belt to fail.
Consequence: A failure of the timing belt may cause the engine to shut down, potentially increasing the risk of a vehicle crash.
Remedy: Gates will notify owners, and dealers will replace the water pump, free of charge. The recall began during May 2014. Owners may contact The Gates Corporation at 1-303-744-1911.
Notes: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Component: EXTERIOR LIGHTING
Summary: CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence: LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
Remedy: AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Notes: THIS RECALL ONLY PERTAINS TO AAI MOTORSPORTS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES. FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS." CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

Component: EXTERIOR LIGHTING
Summary: CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Remedy: CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Notes: THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY THE VEHICLE MANUFACTURERS. FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS." CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

Component: STEERING:LINKAGES:ROD:RELAY:CONNECTING
Summary: VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE TIE RODS OF THE STEERING ASSEMBLY ARE PROTECTED ON EACH SIDE BY A SEAL TO PREVENT MOISTURE AND DUST PARTICLES FROM ENTERING THE SWIVEL BEARING MECHANISM. IT IS POSSIBLE THAT SOME TIE ROD SEALS MAY NOT SEAL PROPERLY.
Consequence: IF MOISTURE AND/OR DUST PARTICLES ENTER THE SWIVEL BEARING MECHANISM, THE SWIVEL BEARING COULD WEAR OVER TIME DIMINISHING THE STEERING CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE TIE RODS.
Notes: VW RECALL NO. UL/AUDI RECALL NO. KW. OWNER NOTIFICATION BEGAN OCTOBER 5, 1999. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987 OR AUDI AT 1-800-822-2834. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Component: STEERING:LINKAGES:ROD:RELAY:CONNECTING
Summary: VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE TIE RODS OF THE STEERING ASSEMBLY ARE PROTECTED ON EACH SIDE BY A SEAL TO PREVENT MOISTURE AND DUST PARTICLES FROM ENTERING THE SWIVEL BEARING MECHANISM. IT IS POSSIBLE THAT SOME TIE ROD SEALS MAY NOT SEAL PROPERLY.
Consequence: IF MOISTURE AND/OR DUST PARTICLES ENTER THE SWIVEL BEARING MECHANISM, THE SWIVEL BEARING COULD WEAR OVER TIME DIMINISHING THE STEERING CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE TIE RODS.
Notes: OWNER NOTIFICATION BEGAN FEBRUARY 5, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987 OR AUDI AT 1-800-822-2834. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Component: SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM:HOSES, LINES/PIPING, AND FITTINGS
Summary: VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS. A CONTROL VALVE IN THE VACUUM HOSE CONNECTING THE BRAKE BOOSTER TO THE INTAKE MANIFOLD MAY NOT OPEN OR CLOSE FULLY AT TEMPERATURES BELOW -4 F UNDER CERTAIN DRIVING CONDITIONS.
Consequence: THIS CONDITION COULD CAUSE INSUFFICIENT VACUUM TO BE PROVIDED TO THE BRAKE BOOSTER.
Remedy: DEALERS WILL INSTALL A VACUUM BY-PASS SYSTEM INTO VEHICLES OPERATED IN THESE STATES WHICH IS DESIGNED TO PROVIDE SUFFICIENT VACUUM FOR FULL BRAKE ASSIST UNDER ALL WEATHER CONDITIONS.
Notes: OWNER NOTIFICATION BEGAN OCTOBER 9, 1999. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VW AT 1-800-822-8987 OR AUDI AT 1-800-822-2834. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

01/28/2016 · Airbags
TL* THE CONTACT OWNS A 1999 AUDI A4. THE CONTACT STATED THAT WHILE DRIVING, THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER BUT THE CONTACT WAS UNAWARE OF THE DIAGNOSIS. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 308,000.

12/07/2012 · Body / structure
AS I WAS OPENING THE HOOD OF THE CAR TO FILL UP THE WINDOW WASHER, THE HOOD DID NOT STAY UP AS USUAL. IT STARTED TO CLOSE AND IT HIT MY HEAD ON THE WAY DOWN. I AM WONDERING IF THERE HAVE BEEN OTHER REPORTS OF THE SAME INCIDENT. LUCKILY, I SUFFERED ONLY MINOR DAMAGE TO MY HEAD, HOWEVER I HAVE ON GOING HEADACHES AS A RESULT. *TR

04/26/2012 · Brakes
MY AUDI, ALONG WITH THOUSANDS OF OTHERS HAVE HAD THEIR ABS CONTROL UNIT MALFUNCTION BECAUSE OF DESIGN. THIS MALFUNCTION CAUSES THE ABS TO NOT WORK ON THE AFFECTED VEHICLE. VOLKSWAGEN, THE COMPANY THAT PRODUCES AUDIS AND VWS ACTUALLY RECALLED THIS EXACT PART ON THEIR VW VEHICLES, BUT FOR SOME REASON REFUSES TO CORRECT THE PROBLEM FOR THEIR AUDI CUSTOMERS. TH…

01/28/2012 · Engine
THE CAR IS EXPERIENCING UNINTENDED ACCELERATION, USUALLY, BUT NOT ALWAYS, AFTER HEAVY ACCELERATION. OVER 10 OCCURRENCES. CANNOT REMEDY BY PULLING BACK THE ACCELERATOR. CAR MUST BE TURNED OFF AND THE ENGINE MUST RECORD 0 RPM TO REMEDY THE PROBLEM. *TR

12/27/2011 · Wheels / tires
TREAD SEPARATION. I WAS DRIVING WESTBOUND ON I-580, APPROXIMATELY 70 MPH, WHEN THE TREAD ON MY RIGHT FRONT TIRE SEPARATED AND THE TIRE BLEW. I WAS LUCKY TO BE ABLE TO PULL OVER TO THE SIDE OF THE ROAD, WITH THE ASSISTANCE OF OTHER AWARE DRIVERS ON THE HIGHWAY WHO ALLOWED ME TO CHANGE LANES AT A REDUCED SPEED. THE TIRE TREAD DAMAGED THE RIGHT FRONT AREA O…

04/29/2011 · Engine
THE EVENTS THAT LED TO THE FAILURE OF THE CAR IS WHEN IT STARTED TO THROW SMOKE FROM THE EXHAUST AND WE FOUND OUT ABOUT THE FAILURE WHEN WE TOOK IT THE MECHANIC WHO TOLD US THE ENGINE WAS NO GOOD. SO FAR IM LOOKING FOR A NEW ENGINE. *TR

04/08/2011 · Electrical system
BOSCH ABS CONTROL UNIT HAS FAILED CAUSING A FLASHING ABS INDICATOR AND A SOLID BRAKE LIGHT. CAUSE IS ELECTRONIC. MANY DOCUMENTED CASES FOUND ON LINE. ABS WILL NOT ENGAGE. AUDI WILL NOT RECALL, BUT VW HAS RECALLED FOR THE SAME PROBLEM. *TR

04/05/2011 · Brakes
I BOUGHT AN AUDI A4 1999 1.8T FWD. THE NEXT DAY I BOUGHT IT THE ABS ORANGE LIGHT CAME ON & BRAKE LIGHT FLASHING NON-STOP WITH THREE BEEPS WHEN I START THE CAR ITS BEEN LIKE THAT FOR MORE THAN A WEEK. YESTERDAY I TOOK THE CAR TO THE CLOSEST AUDI DEALER AND THEY QUOTE ME 1,200 THAT'S A LOT SINCE THIS PROBLEMS WITH THE ABS UNIT IS POOR MANUFACTURE PROBLEM.…